How To Remove Ac Unit From Roof

The mounting bolts which you can easily access from the interior of your rv.

How to remove ac unit from roof.

I replaced the old dometic unit with this new dometic duo therm brisk 2 air 13500btu. Use a funnel to pour a warm water and bleach mixture into the line. Clean the indoor line at the air conditioner condenser unit. After you get the air conditioner free from the roof it is time to lower it down off the roof.

Here s a look at the inside of a coleman rv air conditioner. Remove the air conditioning unit placing it on its side and take out the sponge rubber gasket. What i normally do is get a hacksaw blade and try and cut some of the gasket and then get a flat bar under the ac between the roof and then pry up and it should come free. The freon lines have to be emptied and evacuated re routed and reconnected then vacuum evacuated again then only a certified a c tech can legally buy enough freon to recharge the unit and they ll have the proper tools to do that.

Keeping your rooftop ac unit clean and functioning duration. I use sealer between the gasket roof when reinstalling it. Shimmy the whole ac cover off in one piece. Your talking about moving the condenser unit from the roof to the ground.

Bleach will kill the algae and water will flush it out. Well that can get pretty expensive. Repeat up to three times to clear the clogged line. First remove the four screws that hold the cover on the air conditioner.

These hold the cover in place over the rooftop ac unit. Removing the roof air conditioning. Removing the main unit from the roof. Use a wonder bar or putty knife to pry loose the caulk and or butyl tape that was used to make a watertight seal on the air conditioner.

When installing the best rv ac unit on rv it s usually sealed to the roof with a sponge rubber gasket which is compressible and requires maintenance. Place the new gasket and reassemble the rooftop unit wiring and plastic housing. Remove the roof top air conditioner cover. At least the roof top portion of the unit.

I removed those and the whole cover slid off in one piece. Sometimes these can get stuck on really good in fact some rv manufacturers will put silicone under the gasket on the roof which makes it impossible for the ac unit to come off. If the gaskets have been there for a long time they will be stuck to the roof. Please review my reroof summary the link is shown below.

The gasket is compressed using 3 4 bolts i e. Removing the roof air conditioning. I ve used a utility knife to cut the gasket making it easier to remove the ac unit. Skip navigation sign in.

It weighs 100 lbs so 2 people will be needed to move it.